|
|
|
|
|
|
TO DO List |
P |
Status |
|
|
|
|
|
Pick up Camaro with
Trailer |
1 |
Completed |
|
Find Donor Car with 5.7L
TPI Engine |
1 |
Completed |
|
Remove Engine from Donor
Car |
1 |
Completed |
|
Rebuilt Engine from Donor
Car |
1 |
Completed |
|
Send Heads for testing |
1 |
Completed |
|
Replace heads with
Rebuilds |
1 |
Completed |
|
Clean Block and Paint |
1 |
Completed |
|
Clean TPI Aluminum
components |
1 |
Completed |
|
Re-Assemble Engine |
1 |
Completed |
|
Install Engine &
Transmission |
1 |
Completed |
|
Sandblast & Paint rear axle |
1 |
Completed |
|
|
Replace Fuel Sender & Strainer |
1 |
Completed |
|
|
Change Gas Tank for Fuel Injection from Donor car |
1 |
Completed |
|
|
Install new rear end with Disc Brakes from Donor car |
1 |
Completed |
|
|
Install Front Torsion & WonderBar |
1 |
Completed |
|
|
Connect Fuel lines |
1 |
Completed |
|
|
Install MAF Sensor |
1 |
Completed |
|
|
Install Exhaust System |
1 |
Completed |
|
|
Change Oil Filter & Add Engine Oil |
1 |
Completed |
|
|
Install Air Filters |
1 |
Completed |
|
|
Replace rear axle brake lines and install Rear Brakes |
1 |
Completed |
|
|
Change Master Cylinder & Proportioning Valve for rear disc brakes. |
1 |
Completed |
|
|
Install Drive shaft with new U-Joint |
1 |
Completed |
|
|
Install cooling fans from donor car |
1 |
Completed |
|
|
Install Exhaust Manifolds |
1 |
Completed |
|
|
Install Transmission cooling lines |
1 |
Completed |
|
|
Bleed Brake System |
1 |
Completed |
|
|
Install Hood Hinges |
1 |
Completed |
|
|
Install Heater Hoses |
1 |
Completed |
|
|
Install Radiator hoses |
1 |
Completed |
|
|
Install Oil cooling lines |
1 |
Completed |
|
|
Connect starter |
1 |
Completed |
|
|
Install Spark Plugs |
1 |
Completed |
|
|
Install Cap & Rotor |
1 |
Completed |
|
|
Install Emissions (AIR) System |
1 |
Completed |
|
|
Install Hood Hinges |
1 |
Completed |
|
|
Move wiring connector from Passenger side to Driver side. |
1 |
Completed |
|
|
Install battery connections |
1 |
Completed |
|
|
Install Brake Vacuum |
1 |
Completed |
|
|
Install AC Compressor |
1 |
Completed |
|
|
Install Serpentine Belt |
1 |
Completed |
|
|
Install Plug Wires |
1 |
Completed |
|
|
Connect Ground Wires & Battery to Starter |
1 |
Completed |
|
|
Install new
Battery |
1 |
Completed |
|
|
Vacuum Lines |
1 |
Completed |
|
|
Add Transmission Fluid |
1 |
Completed |
|
|
Add Coolant |
1 |
Completed |
|
|
Add Fuel! |
1 |
Completed |
|
|
Start Car!!!
Check all fluids. |
1 |
Completed |
|
|
Replace Interior w/ Gray Firebird Interior
- Interior swapped, seats& Front Belts now out for repair. |
2 |
Completed |
|
Change Dash with new dash
w/AC |
2 |
Completed |
|
Replace Brake Vacuum
Switch |
2 |
Completed |
|
Replace Steering Column w/
Auto Column |
2 |
Completed
|
|
Merge Under dash Wiring
harness for Auto Shift Safety & Computer controls |
2 |
Completed
|
|
|
Re-assemble dash and console |
2 |
Completed
|
|
|
Adjust Parking Brake |
2 |
Completed
|
|
|
Install AC Components - Tighten Fittings
and Mount |
2 |
Completed |
|
|
Mount ECM |
2 |
Completed |
|
|
Change under dash vents for A/C |
2 |
Completed |
|
Change Brake
Peddle for Auto Trans Brake Peddle |
2 |
Completed |
|
|
Find 13MM 3/8 drive deep socket - Lost in Garage |
4 |
Completed |
|
Install Light Holder
under dash |
2 |
Completed
|
|
Replace O2 Sensor |
2 |
Completed
|
|
|
Paint under hood while still off car |
2 |
Completed
|
|
|
Install Hood |
2 |
Completed
|
|
Check for
Rattle under car |
2 |
Completed
|
|
Install old
Seats, Seats Belts and Sail Panels when back from repair |
2 |
Completed
|
|
|
Change Insurance |
2 |
Completed |
|
|
Install Stereo and speakers |
3 |
Completed
|
|
|
Hook up Ground and bolt
down pipe at rear of engine |
2 |
Completed |
|
Check Reverse light Wiring |
2 |
Completed |
|
Check car for safety
before sending to Mechanic |
2 |
Completed |
|
|
Check Temperature send
unit for error |
2 |
Completed |
|
|
Ship car to Hamilton for Safety and Emissions Testing |
2 |
Completed |
|
|
Register ownership, Pay PST |
2 |
Completed |
|
|
Paint inside engine compartment |
3 |
Completed |
|
Four Wheel Alignment |
2 |
Completed |
|
Install clip for Flasher |
4 |
|
|
|
Fill holes under hood |
3 |
Completed |
|
|
Clean wheel wells from slick rubber |
4 |
Completed |
|
|
Install new front seats
(in Shipping from PA) |
4 |
Completed |
|
Paint
Touch-up |
3 |
Completed |
|
|
Get Appraisal |
4 |
Completed |
|
Repair Passenger side
power Door Lock, won't unlock |
4 |
Completed |
|
Strip Race rims and polish |
4 |
Completed |
|
Install Slicks on Race
rims |
4 |
Completed |
|
Replace Drivers side kick
panel |
4 |
Completed |
|
Screw down trim |
4 |
Completed |
|
Repair spot on trunk lid
underside |
4 |
Completed |
|
Install Plastic panels
under front of car |
4 |
|
|
Install new Stereo CD |
4 |
Completed |
|
Install R134a A/C
Conversion Kit (Include new Evaporator) |
4 |
Completed |
|
Charge A/C - Hamilton
(Change Line and Replace Compressor) |
4 |
Completed |
|
Coat Leather steering
wheel |
4 |
Completed |
|
Replace Ignition Cylinder
with New |
4 |
Completed |
|
Replace Centre Link and
Idler Arm with new |
4 |
|
|
Install drivers side Power
Seat Track |
4 |
Completed |
|
Install Chevrolet A/C
Controller |
4 |
Completed |
|
Repair Cruise Control |
4 |
Completed |
|
Replace Temperature Sender |
4 |
Completed |
|
Strip car for painting |
5 |
Completed |
|
Clean ground effects, etc with pressure
sprayer, prepare for painting |
5 |
Completed |
|
Paint Car |
5 |
Completed |
|
Replace Convertible Top (Danaged ffrom
flying wood on highway) |
5 |
Completed |
|
Re-assemble car after paint |
5 |
Completed |
